Yesterday's Tractor Co.
Shop Now View Cart
   Allis Chalmers Case Farmall IH Ford 9N,2N,8N Ford
   Ferguson John Deere Massey Ferguson Minn. Moline Oliver
 FAQFAQ   SearchSearch   MemberlistMemberlist   UsergroupsUsergroups   Traditional YT Forum ViewClassic View   RegisterRegister 
 ProfileProfile    Log inLog in 

International 606 Diesel problem


 
Post new topic    
View previous topic :: View next topic  
Author Message
asorber
New User


Joined: 19 Dec 2017
Posts: 1


Report to Moderator

PostPosted: Tue Dec 19, 2017 8:23 am    Post subject: International 606 Diesel problem Reply to specific post Reply with quote

Hello Everyone, New to this site, but not new to tractors. This summer I purchased an IH 606 with the d-236 engine. Previous owner put on a brand new roosa master injection pump. Tractor will only start on ether. (all glow plugs are working), and no I am not using ether with the glow plugs. Also tractor runs hot, doesnt overheat, but runs hot enough to drip out of radiator overflow. I flushed the radiator,oil cooler, water pump impeller is working, new thermostat, fan belt is tight. Previous owner had head gasket replaced also a few years back. He said it didnt overheat for him but he had not really used it since the new injection pump was put on. Im thinking possibly a timing issue with pump. Suggestions???
 
Back to top
View user's profile
Dieseltech
Tractor Guru


Joined: 29 Feb 2012
Posts: 6091
Location: Indiana

Report to Moderator

PostPosted: Tue Dec 19, 2017 8:40 am    Post subject: Re: International 606 Diesel problem Reply to specific post Reply with quote

Has the timing been checked? Even when new the D236 was a lousy starter, best way to fix it is put D282 crank and pistons in, and rework the cylinder head so ALL valves are flush. Then the compression heat will be higher to correct the hard starting.
 
Back to top
View user's profile
Jon Hagen
Tractor Expert


Joined: 05 Mar 2009
Posts: 2578


Report to Moderator

PostPosted: Wed Dec 20, 2017 2:30 pm    Post subject: Re: International 606 Diesel problem Reply to specific post Reply with quote

I have that same engine in a little Hough 30B payloader. How long are you holding the glow plug button before attempting to start it ? Mine may need 1/2 -1 minute on the glow plugs before cranking, but it always starts no matter how cold. Never have needed starting fluid. Check your pump timing and make sure the glow plugs are OK. You need fairly long preheat time for any cold start, even in summer.
 
Back to top
View user's profile
Display posts from previous:   
Post new topic    Yesterday's Tractors Forum Index -> Restoration and Repair Tips All times are GMT - 8 Hours
Page 1 of 1

 
Jump to:  

TRACTOR PARTS TRACTOR MANUALS
Fast Shipping!  Most of our stocked parts ship within 24 hours (M-Th). Expedited shipping available, just call! Most prices for parts and manuals are below our competitors. Compare our super low shipping rates! We have the parts you need to repair your tractor. We are a company you can trust and have generous return policies. Shop Online Today or call our friendly sales staff toll free (800) 853-2651. [ About Us ]

YT Home  |  Forums

Modern View Forum powered by phpBB © 2001, 2005 phpBB Group

All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy

TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.

Yesterday's Tractors - Antique Tractor Headquarters