Yesterday's Tractor Co.
Shop Now View Cart
   Allis Chalmers Case Farmall IH Ford 9N,2N,8N Ford
   Ferguson John Deere Massey Ferguson Minn. Moline Oliver
 FAQFAQ   SearchSearch   MemberlistMemberlist   UsergroupsUsergroups   Traditional YT Forum ViewClassic View   RegisterRegister 
 ProfileProfile    Log inLog in 

New Holland LB620 trouble shooting


 
Post new topic    
View previous topic :: View next topic  
Author Message
15DenaliSummit
New User


Joined: 01 Jun 2020
Posts: 2


Report to Moderator

PostPosted: Wed Nov 10, 2021 7:33 am    Post subject: New Holland LB620 trouble shooting Reply to specific post Reply with quote

Since my last post on my IH430, I've had a few tractors in between that and this one. So, on to my issue. This is a mid 80s articulating TLB with an Onan/Edison L423 or also known as a Cummins 4A series. I had to do the injection pump since it fried on me from the unit sitting half its life(it only has 1300 hours). I did that and it smoked and bogged after. I then did the injectors, which was a nightmare since 2 of the 4 injectors snapped off in the cylinder head. So, I pulled the head and got them out, then reinstalled the head and a put new headgasket. It still smoked and bogged then I rechecked the static timing on the pump. I had the static timing off about 30 degrees, I had it set at 15 degrees ATC instead of 15 degrees BTC. After all this, the smoking issue was solved but the bog and low power remained. I then installed an electric lift pump instead of the cam driving one, which helped but still wasn't the solution. I am at a standstill with this engine, because I have done everything that could go wrong on the fuel side. Before these issues, the engine and everything worked great. The engine had great compression and never needed glow plugs to start. Now, it still has great compression, but doesn't like to start cold, which doesn't make sense to me since it was fine right before and during the time I was diagnosing the bad pump. Whenever I have been running the engine doing tests there has been no airfilter on it to eliminate that problem, and I set the valve lash when I put the head back on. I also tested the engine running a auxiliary fuel tank with fresh diesel and it didn't change anything. Any thoughts or ideas to check would be appreciated. I am curious if this could be an issue with the injection pump again, specifically the governor as I don't have much faith in the injection pump shop I went to, they were the only shop local to me within 60 miles.
 
Back to top
View user's profile
:   
Post new topic    Yesterday's Tractors Forum Index -> Today's Tractors All times are GMT - 8 Hours
Page 1 of 1

 
Jump to:  

TRACTOR PARTS TRACTOR MANUALS
We sell tractor parts!  We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]

YT Home  |  Forums

Modern View Forum powered by phpBB © 2001, 2005 phpBB Group

All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy

TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.

Yesterday's Tractors - Antique Tractor Headquarters