Yesterday's Tractor Co.
Shop Now View Cart
   Allis Chalmers Case Farmall IH Ford 9N,2N,8N Ford
   Ferguson John Deere Massey Ferguson Minn. Moline Oliver
 FAQFAQ   SearchSearch   MemberlistMemberlist   UsergroupsUsergroups   Traditional YT Forum ViewClassic View   RegisterRegister 
 ProfileProfile    Log inLog in 

Belarus 572 Wiring


 
Post new topic    
View previous topic :: View next topic  
Author Message
Gumby13
New User


Joined: 07 Feb 2019
Posts: 5


Report to Moderator

PostPosted: Sun Feb 10, 2019 6:45 pm    Post subject: Belarus 572 Wiring Reply to specific post Reply with quote

Working on wiring on a Belarus 572.

New to this and basically have little idea of what I?m doing.
I come to this website for help understanding wiring diagram. I have
been able to follow and identify some wires but especially
Confused when it comes to ignition switch paths and understanding
what wire is the hot feed from battery. Any help is appreciated.







 
Back to top
View user's profile
Dieseltech
Tractor Guru


Joined: 29 Feb 2012
Posts: 7248
Location: Indiana

Report to Moderator

PostPosted: Sun Feb 10, 2019 7:07 pm    Post subject: Re: Belarus 572 Wiring Reply to specific post Reply with quote

If it's like mine it has a series-parallel switch for 24V start, and 12V charging and lights. Switch is between the two 12V batteries behind the seat. I keep the ground disconnect switch in off position and only turn it on to use the tractor.
 
Back to top
View user's profile
Gumby13
New User


Joined: 07 Feb 2019
Posts: 5


Report to Moderator

PostPosted: Sun Feb 10, 2019 7:20 pm    Post subject: Re: Belarus 572 Wiring Reply to specific post Reply with quote

Thank you for the reply.

Yes, mine also has the parallel switch between the batteries. I understand that when the key is in the cranking position that it engages that switch so 24v are sent to starter.. I?m just having trouble understanding where the ignition gets it power from the starter because to me it doesn?t look like the attached wiring diagrams the service manual contains shows what wire runs from starter to ignition. Are you able to see it? Anyone?
 
Back to top
View user's profile
Bob
Tractor Guru


Joined: 03 Jan 1998
Posts: 53113


Report to Moderator

PostPosted: Sun Feb 10, 2019 7:35 pm    Post subject: Re: Belarus 572 Wiring Reply to specific post Reply with quote


I's a pretty simple circuit, really.

I've put some notes on the diagram, use at your own risk.

When not cranking, both batteries supply 12 Volts to the "30" terminal on the S/P switch, and I've marked in red it's path to the Ammeter. The alternator and many loads connect to the other side of the ammeter.

Note the two 50 Amp fuses on the S/P switch, one for each battery, which protect the charging and accessory circuits fed from each.

What issue are you having?







 
Back to top
View user's profile
Gumby13
New User


Joined: 07 Feb 2019
Posts: 5


Report to Moderator

PostPosted: Sun Feb 10, 2019 8:02 pm    Post subject: Re: Belarus 572 Wiring Reply to specific post Reply with quote

Bob,

I really appreciate this. I?m a 28 year old computer nerd who was
inspired by a YouTube video to rebuild the hydrolocked engine of my
Grandpap?s tractor, which was my ?favorite? growing up. It sat for 15
years rotting away and I?m getting so close to bringing it back.

I am going to print the notes you?ve done for me off. The whole wiring
task is pretty overwhelming for me due to not having any experience
at all. I don?t understand what I?m looking at so I?m just trying to learn
as much as I can.

Thanks again for helping and I apologize for the backstory if you
didn?t care to read it.

If I may pick your brain a bit... does that mean that the ignition is tied
in from a hot wire that goes to the ammeter?
 
Back to top
View user's profile
Gumby13
New User


Joined: 07 Feb 2019
Posts: 5


Report to Moderator

PostPosted: Sun Feb 10, 2019 8:26 pm    Post subject: Re: Belarus 572 Wiring Reply to specific post Reply with quote

Forgot to answer your question, really.

The issue is just that we are waiting on a new SP switch now because of old one was completely rusted out inside but before we discovered that we were trying to hook the starter up to the wires that ran from the cab but weren?t sure we were doing it right... so I?m trying to get a better understanding of what this diagram says anyway I can.

For example on the tractor... there?s a thick wire that runs to starter from back left battery suppling constant 12v. But from what I remember there are two wires that ran from the starter to the cab.. a purple and a orange one.. I followed them to a plug under the dash... and eventually traced one back to the sp switch.. but this plug I mentioned. On one side there are 4 wires running into it and on the other side only three. I just don?t get it well enough yet and why there?s a wire ran that doesn?t connect to anything? the diagram even shows three wires running out of this plug, one to the starter. I have an extra I?m not sure about?
 
Back to top
View user's profile
Bates-Interceptor
New User


Joined: 19 Mar 2019
Posts: 2


Report to Moderator

PostPosted: Tue Mar 19, 2019 6:15 pm    Post subject: Re: Belarus 572 Wiring Reply to specific post Reply with quote

Grate stuff man helped me with 12to24 switch between batterys she is a big bad relay lol
 
Back to top
View user's profile
Bates-Interceptor
New User


Joined: 19 Mar 2019
Posts: 2


Report to Moderator

PostPosted: Tue Mar 19, 2019 6:43 pm    Post subject: Re: Belarus 572 Wiring Reply to specific post Reply with quote

Terminal 50a is control from key, if you are standing on the back of tractor it is between the switch and the right battery. In the middle of switch the wire was green for the 572 I was working on. There is three, top is right battery positive terminal big red wire under that one is a small green wire from control on terminal 50a. Then under that is fuse link and blue or purple wire on it. Thats how mine was.
 
Back to top
View user's profile
:   
Post new topic    Yesterday's Tractors Forum Index -> Restoration and Repair Tips All times are GMT - 8 Hours
Page 1 of 1

 
Jump to:  

TRACTOR PARTS TRACTOR MANUALS
Fast Shipping!  Most of our stocked parts ship within 24 hours (M-Th). We have the parts you need to repair your tractor - the right parts. Our fast shipping, low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]

YT Home  |  Forums

Modern View Forum powered by phpBB © 2001, 2005 phpBB Group

All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy

TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.

Yesterday's Tractors - Antique Tractor Headquarters